氨气吸附材料的研究进展

doi:10.12034/j.issn.1009-606X.218171

过程工程学报 ›› 2019, Vol. 19 ›› Issue (1): 14-24.DOI: 10.12034/j.issn.1009-606X.218171

氨气吸附材料的研究进展

王均利^{1, 2}，曾少娟^1*，陈能³，尚大伟¹，张香平^1*，李建伟²

1. 中国科学院过程工程研究所多相复杂系统国家重点实验室，离子液体清洁过程北京市重点实验室，北京 100190
2. 北京化工大学化工资源有效利用国家重点实验室，北京 100029
3. 中国石油大学(北京)化学工程学院，北京 102249

收稿日期:2018-04-03 修回日期:2018-05-09 出版日期:2019-02-22 发布日期:2019-02-12
通讯作者: 张香平 xpzhang@ipe.ac.cn
基金资助:
基于含氟烟气净化的介孔氧化铝的可控合成基础研究;北京市自然基金

Research progress of ammonia adsorption materials

Junli WANG^1,2, Shaojuan ZENG^1*, Neng CHEN³, Dawei SHANG¹, Xiangping ZHANG^1*, Jianwei LI²

1. State Key Laboratory of Multiphase Complex Systems, Beijing Key Laboratory of Ionic Liquids Clean Process, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, China
2. State Key Laboratory of Chemical Resource Engineering, Beijing University of Chemical Technology, Beijing 100029, China
3. School of Chemical Engineering, China University of Petroleum, Beijing 102249, China

Received:2018-04-03 Revised:2018-05-09 Online:2019-02-22 Published:2019-02-12
Contact: xiangping zhang xpzhang@ipe.ac.cn
Supported by:
Fundamental Research on the Controllable Synthesis of Mesoporous Alumina for the Purification of Fluorine Flue Gas

摘要/Abstract

摘要： 氨是一种典型的有毒有害气态碱性污染物，也是PM2.5二次颗粒物的主要成因之一，大量含氨尾气排放不仅严重影响人类健康和生活环境，还会造成氨资源浪费。本工作综述了近年来多孔材料用于氨气吸附分离的研究现状和进展，重点论述了沸石、硅胶、活性炭、氧化石墨烯、多孔有机聚合物、共价有机骨架和金属?有机骨架材料改性前后对氨气的吸附性能，总结了吸附材料的改性方法，分析了该领域发展面临的主要问题，对未来的研究方向提出了建议。

关键词: 氨气, 气体分离, 吸附, 离子液体, 多孔材料

Abstract: Ammonia is a typical toxic pollutant and also one of the main causes of the formation of PM2.5. The emission of industrial tail gases containing a large amount of ammonia not only seriously affects the environment and health of human beings, but also results in serious waste of ammonia sources if directly discharged into the atmosphere. Because of their abundant pore structures and large specific surface areas, good adsorption characteristics and mechanical stability, porous materials have attracted a lot of attention in gas adsorption, especially in ammonia removal. Different porous materials can effectively absorb ammonia through the physical or chemical interaction between ammonia and their special pore structures or action sites. The adsorption method for ammonia removal has the several advantages, such as high selectivity, easy recovery and low energy consumption, so it is widely used in many industrial processes. In this review, the recent research status and progress of ammonia removal using different porous materials were reviewed, mainly focused on the research around the ammonia adsorption performances of zeolite, silica gel, activated carbon, graphene oxide, porous organic polymer, covalent organic frameworks (COFs), metal?organic frameworks (MOFs) materials before and after modification, and the research progress of supported ionic liquids materials for ammonia separation in recent years was also introduced. Ionic liquids, as a class of green medium, have several unique advantages for ammonia removal, such as low vapor pressure, high gas selectivity, high thermal stability, tunable structures and properties. Supported ionic liquids materials can combine the characteristics of both ionic liquids and porous materials, which can break the traditional restriction of ionic liquids in industrial applications and providing a novel pathway for ammonia removal applications. Finally, given the main problems of the current development on ammonia removal and recovery using porous materials, the future research directions and solutions had been put forward.

Key words: ammonia, gas separation, adsorption, ionic liquid

王均利曾少娟陈能尚大伟张香平李建伟. 氨气吸附材料的研究进展[J]. 过程工程学报, 2019, 19(1): 14-24.

Junli WANG Shaojuan ZENG Neng CHEN Dawei SHANG Xiangping ZHANG Jianwei LI. Research progress of ammonia adsorption materials[J]. Chin. J. Process Eng., 2019, 19(1): 14-24.

参考文献

[1] N.A. Travlou, T.J. Bandosz. N-doped polymeric resin-derived porous carbons as efficient ammonia removal and detection media[J]. Carbon , 2017, 117: 228-239.
[2] J.W. Erisman, A. Bleeker, J. Galloway, M.S. Sutton. Reduced nitrogen in ecology and the environment[J]. Environmental Pollution, 2007, 150: 140-149.
[3] A. Yokozeki, M.B. Shiflett.. Ammonia solubilities in room-temperature ionic liquids[J]. Industrial & Engineering Chemistry Research, 2007, 46 : 1605-1610.
[4] J.J. Zhu, D.H. Xiao, J. Li, X.G. Yang, Y. Wu. Effect of Ce on NO direct decomposition in the absence/presence of O2 over La1-xCexSrNiO4 （0 <= x <= 0.3） [J]. Journal of Molecular Catalysis a-Chemical, 2005, 234 : 99-105.
[5] J.L. Hueso, J. Cotrino, A. Caballero, J.P. Espinos, A.R. Gonzalez-Elipe. Plasma catalysis with perovskite-type catalysts for the removal of NO and CH4 from combustion exhausts[J]. Journal of Catalysis, 2007, 247: 288-297.
[6] W. Zheng, J. Hu, S. Rappeport, Z. Zheng, Z. Wang, Z. Han, J. Langer, J. Economy, Activated carbon fiber composites for gas phase ammonia adsorption[J]. Microporous and Mesoporous Materials, 2016, 234 : 146-154.
[7] 许俊香, 刘本生, 孙钦平等. 沸石添加剂对污泥堆肥过程中的氨挥发及相关因素的影响[J]. 农业资源与环境学报, 2015, 32（1）:81-86.
XU Jun-xiang, LIU Ben-sheng, SUN Qin-ping, et al. Effects of Zeolite Addition on Ammonia Volatilization and Influence Factors in Sludge Composting[J]. Journal of Agricultural Resources and Environment, 2015, 32:81-86.
[8] 王秀艳, 刘长礼. 对粘性土孔隙水渗流规律本质的新认识[J]. 地球学报, 2003,24（1）: 91-95.
WANG Xi uyan , LI U Changli. New understandi ng of t he regularity of water seepage i n Cohesive soil[J]. acta geoscientia sinica, 2003,24（1）: 91-95.
[9] A. Srebowata, R. Baran, D. Lomot, D. Lisovytskiy, T. Onfroy, S. Dzwigaj. Remarkable effect of postsynthesis preparation procedures on catalytic properties of Ni-loaded BEA zeolites in hydrodechlorination of 1,2-dichloroethane[J]. Applied Catalysis B-Environmental, 2014, 147: 208-220.
[10] M.P. Bernal, J.M. Lopezreal. NATURAL ZEOLITES AND SEPIOLITE AS AMMONIUM AND AMMONIA ADSORBENT MATERIALS[J]. Bioresource Technology, 1993, 43: 27-33.
[11] J. Helminen, J. Helenius, E. Paatero, I. Turunen. Adsorption equilibria of ammonia gas on inorganic and organic sorbents at 298.15 K[J]. Journal of Chemical and Engineering Data , 2001, 46 : 391-399.
[12] 翁晴. 改性沸石在水处理中的应用[J]. 山东化工, 2014, 43（1）: 54-55.
WENG Qing. The Application of Modify Zeolite in Water Treatment[J]. Shandong chemical industry, （2014） 54-55.
[13] T.G. Glover, G.W. Peterson, B.J. Schindler, D. Britt, O. Yaghi. MOF-74 building unit has a direct impact on toxic gas adsorption[J]. Chemical Engineering Science , 2001, 66: 163-170.
[14] E. Witter, H. Kirchmann, PEAT. ZEOLITE AND BASALT AS ADSORBENTS OF AMMONIACAL NITROGEN DURING MANURE DECOMPOSITION[J]. Plant and Soil, 1989, 115: 43-52.
[15] 万政钰. 利用改性沸石吸附剂处理氨气的研究[D]. 吉林大学, 2009.
Wan Zhengyu, Study on the Treatment of Ammonia Using Modified Zeolite Adsorbent[D]. Jilin University, 2009.
[16] H. Taghipour, M.R. Shahmansoury, B. Bina, H. Movahdian. Operational parameters in biofiltration of ammonia-contaminated air streams using compost-pieces of hard plastics filter media[J]. Chemical Engineering Journal, 2008, 137 : 198-204.
[17] 杨国华, 黄统琳, 姚忠亮,等. 吸附剂的应用研究现状和进展[J]. 化学工程与装备, 2009, 6:83-88.
Yang Guo Hua, Huang Tong Lin, Yao Zhongliang, et al. Current Application Research on the Adsorbents and Their Development Tendency[J]. Chemical Engineering&Equipment, 2009, 6:83-88.
[18] 张滢, 张景成, 崔自敏, 等. 铝基吸附剂去除饮用水中氟的研究进展[J]. 环境科学与技术, 2012, 35（4）: 93-98.
ZHANG Ying, ZHANG Jing-cheng, CUI Zimin, et al. Development of Alumina-based Materials in Defluoridation of Drinking Water[J]. Environmental Science&Technology, 2012, 35（4）: 93-98.
[19] S. Abe, T. Sawane, K. Sekiguchi, T. Matsuo. COLLECTION OF TRACE FLUORIDE AND HYDROFLUORIC-ACID FROM AQUEOUS SAMPLES BY CALCIUM HYDROXYAPATITE[J]. International Journal of Environmental Analytical Chemistry, 1982, 11: 87-96.
[20] V.E. Sharonov, Y.I. Aristov. Ammonia adsorption by MgCl2, CaCl2 and BaCl2 confined to porous alumina: The fixed bed adsorber[J]. Reaction Kinetics and Catalysis Letters, 2005, 85: 183-188.
[21] D. Saha, S.G. Deng. Characteristics of Ammonia Adsorption on Activated Alumina[J]. Journal of Chemical and Engineering Data, 2010, 55: 5587-5593.
[22] C. Yeom, Y. Kim. Adsorption of ammonia using mesoporous alumina prepared by a templating method[J]. Environmental Engineering Research, 2017, 22 : 401-406.
[23] 管蒙蒙, 邱建勋, 高修涛, 等. Sol-gel法制备多孔氧化铝及其对甲醛的吸附研究[J]. 山东化工, 2008, 37（4）: 4-6+10.
GUAN Mengmeng, QIU JianXun, GAO Xiutao, et al. Research on Preparation of Alumina with Sol-gel Method and Its Adsorption Property for Formaldehyde [J]. Shandong chemical industry, 2008, 37（4）: 4-6+10.
[24] S. Kittaka, M. Morimura, S. Ishimaru, A. Morino, K. Ueda. Effect of Confinement on the Fluid Properties of Ammonia in Mesopores of MCM-41 and SBA-15[J]. Langmuir, 2009, 25: 1718-1724.
[25] A.M.B. Furtado, Y. Wang, T.G. Glover, M.D. LeVan. MCM-41 impregnated with active metal sites: Synthesis, characterization, and ammonia adsorption[J]. Microporous and Mesoporous Materials, 2011, 142 : 730-739.
[26] H. Fortier, P. Westreich, S. Selig, C. Zelenietz, J.R. Dahn. Ammonia, cyclohexane, nitrogen and water adsorption capacities of an activated carbon impregnated with increasing amounts of ZnCl2, and designed to chemisorb gaseous NH3 from an air stream[J]. J. Colloid Interface Sci, 2008, 320: 423-435.
[27] A.M. Furtado, D. Barpaga, L.A. Mitchell, Y. Wang, J.B. DeCoste, G.W. Peterson, M.D. Levan. Organoalkoxysilane-grafted silica composites for acidic and basic gas adsorption[J]. Langmuir, 2012, 28: 17450-17456.
[28] A.M.B. Furtado, Y. Wang, M.D. LeVan. Carbon silica composites for sulfur dioxide and ammonia adsorption[J]. Microporous and Mesoporous Materials, 2013, 165 : 48-54.
[29] A.M.B. Furtado, J. Liu, Y. Wang, M.D. LeVan. Mesoporous silica–metal organic composite: synthesis, characterization, and ammonia adsorption[J]. Journal of Materials Chemistry, 2011, 21 :6698.
[30] H.S. Teng, T.S. Yeh, L.Y. Hsu. Preparation of activated carbon from bituminous coal with phosphoric acid activation[J]. Carbon , 1998,36: 1387-1395.
[31] C.-C. Huang, H.-S. Li, C.-H. Chen. Effect of surface acidic oxides of activated carbon on adsorption of ammonia[J]. Journal of hazardous materials ,2008,159 :523-527.
[32] A. Qajar, M. Peer, M.R. Andalibi, R. Rajagopalan, H.C. Foley. Enhanced ammonia adsorption on functionalized nanoporous carbons[J]. Microporous and Mesoporous Materials, 2015, 218: 15-23.
[33] X.S.S.Z.W. Zhang. Effect of surface modification of activated carbon on its adsorption capacity for NH3[J]. Journal of China University of Mining & Technology, 2008,18: 0261-0265.
[34] C. Petit, C. Karwacki, G. Peterson, T.J. Bandosz. Interactions of ammonia with the surface of microporous carbon impregnated with transition metal chlorides[J]. Journal of Physical Chemistry C, 2007, 111: 12705-12714.
[35] C. Petit, K. Kante, T.J. Bandosz. The role of sulfur-containing groups in ammonia retention on activated carbons[J]. Carbon, 2010, 48 : 654-667.
[36] M. Seredych, T.J. Bandosz. Mechanism of ammonia retention on graphite oxides: Role of surface chemistry and structure[J]. Journal of Physical Chemistry C,2007, 111:15596-15604.
[37] M. Seredych, A.V. Tamashausky, T.J. Bandosz. Graphite Oxides Obtained from Porous Graphite: The Role of Surface Chemistry and Texture in Ammonia Retention at Ambient Conditions[J]. Advanced Functional Materials, 2010, 20: 1670-1679.
[38] T. Ben, H. Ren, S. Ma, D. Cao, J. Lan, X. Jing, W. Wang, J. Xu, F. Deng, J.M. Simmons, S. Qiu, G. Zhu. Targeted Synthesis of a Porous Aromatic Framework with High Stability and Exceptionally High Surface Area[J]. Angewandte Chemie-International Edition, 2009, 48 : 9457-9460.
[39] J.F. Van Humbeck, T.M. McDonald, X. Jing, B.M. Wiers, G. Zhu, J.R. Long. Ammonia capture in porous organic polymers densely functionalized with Bronsted acid groups[J]. J Am Chem Soc, 2014, 136: 2432-2440.
[40] D.T. McQuade, A.E. Pullen, T.M. Swager. Conjugated polymer-based chemical sensors[J]. Chemical reviews, 2000, 100 :2537-2574.
[41] C.J. Doonan, D.J. Tranchemontagne, T.G. Glover, J.R. Hunt, O.M. Yaghi. Exceptional ammonia uptake by a covalent organic framework[J]. Nature Chemistry, 2010, 2: 235-238.
[42] W.-J. Kim. Studies on Adsorption and Desorption of Ammonia Using Covalent Organic Framework COF-10[J]. Applied Chemistry for Engineering, 2016, 27 : 265-269.
[43] Y. Li, R.T. Yang. Hydrogen storage in metal-organic and covalent-organic frameworks by spillover[J]. Aiche Journal, 2008, 54: 269-279.
[44] P. Kuhn, M. Antonietti, A. Thomas, Porous. covalent triazine-based frameworks prepared by ionothermal synthesis[J]. Angewandte Chemie-International Edition, 2008, 47: 3450-3453.
[45] D. Britt, D. Tranchemontagne, O.M. Yaghi. Metal-organic frameworks with high capacity and selectivity for harmful gases[J]. Proceedings of the National Academy of Sciences of the United States of America, 2008, 105: 11623-11627.
[46] D. Saha, S. Deng. Ammonia adsorption and its effects on framework stability of MOF-5 and MOF-177[J]. Journal of Colloid and Interface Science, 2010, 348: 615-620.
[47] C. Petit, T.J. Bandosz. Enhanced Adsorption of Ammonia on Metal-Organic Framework/Graphite Oxide Composites: Analysis of Surface Interactions[J]. Advanced Functional Materials, 2010, 20: 111-118.
[48] C. Petit, L. Huang, J. Jagiello, J. Kenvin, K.E. Gubbins, T.J. Bandosz. Toward Understanding Reactive Adsorption of Ammonia on Cu-MOF/Graphite Oxide Nanocomposites[J]. Langmuir, 2011, 27: 13043-13051.
[49] G.W. Peterson, G.W. Wagner, A. Balboa, J. Mahle, T. Sewell, C.J. Karwacki. Ammonia Vapor Removal by Cu-3（BTC）（2） and Its Characterization by MAS NMR[J]. Journal of Physical Chemistry C, 2009, 113: 13906-13917.
[50] B. Tan, C. Chen, L.-X. Cai, Y.-J. Zhang, X.-Y. Huang, J. Zhang. Introduction of Lewis Acidic and Redox-Active Sites into a Porous Framework for Ammonia Capture with Visual Color Response[J]. Inorg Chem, 2015, 54 :3456-3461.
[51] Y. Chen, L. Li, J. Li, K. Ouyang, J. Yang. Ammonia capture and flexible transformation of M-2（INA）（M = Cu, Co, Ni, Cd） series materials[J]. Journal of hazardous materials, 2016, 306 : 340-347.
[52] F.T.U. Kohler, S. Popp, H. Klefer, I. Eckle, C. Schrage, B. B?hringer, D. Roth, M. Haumann, P. Wasserscheid. Supported ionic liquid phase （SILP） materials for removal of hazardous gas compounds – efficient and irreversible NH3 adsorption[J]. Green Chemistry, 2014, 16: 3560-3568.
[53] K.N. Ruckart, Y. Zhang, W.M. Reichert, G.W. Peterson, T.G. Glover. Sorption of Ammonia in Mesoporous-Silica Ionic Liquid Composites[J]. Industrial & Engineering Chemistry Research ,2016, 55: 12191-12204.

氨气吸附材料的研究进展

Research progress of ammonia adsorption materials

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	赵晓腾周新涛罗中秋韦宇兰雄陆艳. 二氧化钛基复合材料对常见染料的去除性能及其机理研究进展[J]. 过程工程学报, 2022, 22(9): 1169-1180.
[2]	兰雄刘钦周新涛罗中秋赵晓腾陆艳. 吸附法脱除废水中四环素的研究进展[J]. 过程工程学报, 2022, 22(8): 989-1000.
[3]	马肃戴毅. 含有偶氮苯结构单元的离子液体在智能材料中的应用与研究进展[J]. 过程工程学报, 2022, 22(8): 1011-1018.
[4]	陶润萍董伟强胡庆松朱靖王智鑫徐轶群. Brij30/β-FeOOH/GO复合材料的可控构筑及其对盐酸四环素吸附性能[J]. 过程工程学报, 2022, 22(7): 979-988.
[5]	韩娟方思含黄文睿吴嘉聪李媛媛王蕾毛艳丽王赟. 泡沫分离设备的研究进展[J]. 过程工程学报, 2022, 22(7): 839-852.
[6]	聂发辉吴道黄慧倩徐志威吴钦刘占孟. Fe3O4@SA/CTS凝胶球对亚甲基蓝及碱性品红的吸附[J]. 过程工程学报, 2022, 22(6): 734-744.
[7]	肖邦曹青马培勇毕海林李鹏程. 基于分子动力学模拟的羟基改性调控活性炭对甲苯吸附性能的作用机理研究[J]. 过程工程学报, 2022, 22(5): 660-670.
[8]	仪凡贺鹏曹俊雅曹妍王利国陈家强李会泉. CaY分子筛对乙二醇和1,2-丁二醇吸附分离性能的研究[J]. 过程工程学报, 2022, 22(4): 448-457.
[9]	李燕郭昌进丁磊. 磁性离子交换树脂强化水源中有机物去除性能研究[J]. 过程工程学报, 2022, 22(4): 542-551.
[10]	张亚卓战金辉. CH₃Cl在ZnO(001)和ZnO(100)表面吸附的第一性原理计算[J]. 过程工程学报, 2022, 22(2): 240-248.
[11]	胡美清金伟. 电吸附-电沉积联合作用下的低浓度铜离子分离[J]. 过程工程学报, 2021, 21(8): 976-984.
[12]	李小亮, 田国才. 盐酸在黄铜矿表面吸附机制的第一性原理计算[J]. 过程工程学报, 2021, 21(7): 836-846.
[13]	胡天媛, 王艳磊, 霍锋, 何宏艳. 短链多硫化物在离子液体中聚集行为的分子动力学模拟[J]. 过程工程学报, 2021, 21(7): 847-856.
[14]	张智霖, 丁磊, 周强, 余剑, 郭昌进, 张德伟. 响应曲面法优化木薯酒精污泥基活性炭制备及对没食子酸的吸附性能[J]. 过程工程学报, 2021, 21(7): 794-806.
[15]	李凌, 丁磊, 薛岗, 贾韫翰, 钟梅英, 张德伟. 不同亲疏水性腐殖酸对磁性离子交换树脂吸附去除水中溴离子的影响[J]. 过程工程学报, 2021, 21(7): 807-816.