具有双层桨结构的自吸式搅拌反应器的流体力学性能

doi:10.12034/j.issn.1009-606X.219113

过程工程学报 ›› 2019, Vol. 19 ›› Issue (6): 1066-1074.DOI: 10.12034/j.issn.1009-606X.219113

具有双层桨结构的自吸式搅拌反应器的流体力学性能

韩愈，包雨云，马鑫，蔡子琦，高正明*

北京化工大学化学工程学院，北京 100029

收稿日期:2019-01-02 修回日期:2019-03-29 出版日期:2019-12-22 发布日期:2019-12-22
通讯作者: 高正明 gaozm@mail.buct.edu.cn
基金资助:
国家重点研发计划;国家自然科学基金项目

Hydrodynamics performance of self-inducing stirred tank equipped with double impellers

Yu HAN, Yuyun BAO, Xin MA, Ziqi CAI, Zhengming GAO*

College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China

Received:2019-01-02 Revised:2019-03-29 Online:2019-12-22 Published:2019-12-22
Contact: GAO Zheng-ming gaozm@mail.buct.edu.cn
Supported by:
National Key R&D Program of China

摘要/Abstract

摘要： 在直径0.48 m的搅拌槽中以水?空气为介质，对具有双层桨结构的自吸式反应器的流体力学性能进行了实验研究，考察了自吸式桨浸没深度、底层桨结构和搅拌桨层间距对自吸式桨的临界吸气转速、吸气速率和气含率的影响。结果表明，临界吸气转速随自吸式桨浸没深度增加而增加，临界吸气转速几乎与下层桨的结构无关；吸气速率与气含率随浸没深度增加而减小，吸气速率与气含率受下层桨影响较大，层间距为自吸式桨直径(D)且采用上推式的四叶宽叶翼形轴流式桨作下层桨时，自吸式桨的吸气性能最佳。

关键词: 自吸式搅拌桨, 临界吸气转速, 组合搅拌桨, 吸气速率, 气含率

Abstract: Stirred tank equipped with a self-inducing impeller is a typical gas–liquid reactor which attracted much concern in recent years. In order to investigate the hydrodynamics characteristics of a four-blade self-inducing impeller and find the optimized impeller combination, experiments were conducted with the air?water system in a tank of 0.48 m diameter. The effects of impeller submergence, impeller spacing and the structure of bottom impeller on the critical impeller speeds of air inducing, gas holdup and gas-inducing rate were investigated. The results showed that the critical impeller speed increased with the increase in impeller submergence, while the critical impeller speed of different double impeller combinations were nearly the same. Although the bottom impeller had a little influence on the critical impeller speed, it obviously influenced global parameters such as the gas-inducing rate and the total gas holdup, which decreased as the impeller submergence increased. Under the same power consumption, when the bottom impeller was WHU (wide hydrofoil pumping up), a good gas-inducing rate and gas holdup were achieved. Impeller spacing also had influence on gas-inducing rate and gas holdup. When the impeller spacing was equal to a diameter of the self-inducing impeller, the latter showed the optimal performance on gas-inducing and gas holdup. The influence of impeller submergence and impeller rotation speed on gas-inducing rate, gas holdup and relative power demand (RPD) of gas-inducing impeller can be taken into account by introducing a modified Froude number to help the design of stirred tank.

Key words: self-inducing impeller, critical impeller speed, impeller combination, gas-inducing rate, gas holdup

韩愈包雨云马鑫蔡子琦高正明. 具有双层桨结构的自吸式搅拌反应器的流体力学性能[J]. 过程工程学报, 2019, 19(6): 1066-1074.

Yu HAN Yuyun BAO Xin MA Ziqi CAI Zhengming GAO. Hydrodynamics performance of self-inducing stirred tank equipped with double impellers[J]. Chin. J. Process Eng., 2019, 19(6): 1066-1074.

参考文献

[1] Hong H S, Cai Z J, Li J Q, et al. Simulation of gas-inducing reactor couples gas–liquid mass transfer and biochemical reaction[J]. Biochemical Engineering Journal, 2014, 91(91):1-9.
[2] 刘甜甜, 李玉刚, 郑世清. CFD在自吸式加氢反应器流场研究中的应用[J]. 化工进展, 2017, 36(3):846-851.
LIU T T, LI Y G, ZHENG S Q. Flow field characteristics of gas-inducing hydrogenation reactor with CFD simulation [J]. Chemical Industry and Engineering Progress, 2017, 36(3):846-851.
[3] Jiang L, Li A, Tang S. An Experimental Study on Carbon Dioxide Hydrate Formation Using a Gas-Inducing Agitated Reactor[J]. Energy, 2017:S0360544217310150.
[4] 张津津, 高正明, 蔡雅婷, et al. 多层组合桨搅拌槽内通气功率和传质性能研究[J]. 北京化工大学学报：自然科学版, 2015, 42(5):41-46.
ZHANG J J, GAO Z M, CAI Y T, et al. Power consumption and mass transfer for various impeller
combinations in a stirred tank[J]. Journal of Beijing University of Chemical Technology ( Natural Science), 2015, 42(5):41-46.
[5] Ye Q , Li Z , Wu H . Principle and Performance of Gas Self-inducing Reactors and Applications to Biotechnology[M]. Springer Berlin Heidelberg, 2015: 1-33.
[6] Zhang J , Gao Z , Cai Y , et al. Power consumption and mass transfer in a gas-liquid-solid stirred tank reactor with various triple-impeller combinations[J]. Chemical Engineering Science, 2017:S0009250917301008.
[7] Achouri R , Hamza S B , Dhaouadi H , et al. Volumetric mass transfer coefficient and hydrodynamic study of a new self-inducing turbine[J]. Energy Conversion and Management, 2013, 71:69-75.
[8] 李波, 张庆文, 洪厚胜. 气体自吸式反应器的研究进展[J]. 化工进展, 2008, 27(11):1728-1735.
LI B, ZHANG Q W, HONG H S. Research progress of gas-inducing reactor [J]. Chemical Industry and Engineering Progress, 2008, 27(11):1728-1735.
[9] 鞠凡，程振民，陈建华，et al.双层桨结构自吸式反应器的气含率[J]. 华东理工大学学报(自然科学版), 2009, 35(5)：667-672.
JU F, CHENG Z M, CHEN J H. Gas Hold-up in a Gas Self-inducing Contactor Equipped with Double Layered Impellers[J]. Journal of East China University of Science and Technology(Natural Science Edition) , 2009, 35(5)：667-672.
[10] Deshmukh N A, Patil S S, Joshi J B. Gas Induction Characteristics of Hollow Self-Inducing Impeller[J]. Chemical Engineering Research & Design, 2006, 84(2):124-132.
[11] 秦佩, 郝惠娣, 冯蓉蓉, et al. 自吸式气液搅拌槽气液分散性能的实验研究[J]. 化工技术与开发, 2012, 41(8):40-43.
QIN P, HAO H D, FENG R R, et al. Experiment Study of Gas-liquid Dispersion Performance Inside Self-inspirating Tank[J]. Technology & Development of Chemical Industry, 2012, 41(8):40-43.
[12] 赵春霞, 满瑞林, 余嘉耕. 自吸式搅拌反应器制备纳米碳酸钙新工艺研究[J]. 非金属矿, 2002, 25(5):20-22.
ZHAO C X, MAN R L, YU J G. A New Process Research on Preparation of Nanometer Calcium Carbonate Using Self-suction Stirred Reactor [J]. Non-Metallic Mines, 2002, 25(5):20-22.
[13] Hsu Y C , Huang C J. Ozone Transfer with Optimal Design of a New Gas-Induced Reactor[J]. Aiche Journal, 2010, 43(9):2336-2342.
[14] Hsu Y C, Chen J T, Yang H C, et al. Decolorization of dyes using ozone in gas-induced a reactor (p 169-176)[J]. Aiche Journal, 2010, 47(1):169-176.
[15] Fonte, Cláudio P, Pinho B S , Santos-Moreau V , et al. Prediction of the Induced Gas Flow Rate from a Self-Inducing Impeller with CFD[J]. Chemical Engineering & Technology, 2014, 37(4):571-579.
[16] Ju F , Cheng Z M , Chen J H , et al. A novel design for a gas-inducing impeller at the lowest critical speed[J]. Chemical Engineering Research & Design, 2009, 87(8):1069-1074.
[17] Raidoo A D, Rao K S M S R, Sawant S B , et al. IMPROVEMENTS IN GAS INDUCING IMPELLER DESIGN[J]. Chemical Engineering Communications, 1987, 54(1-6):241-264.
[18] Poncin S, Nguyen C, Midoux N, et al. Hydrodynamics and volumetric gas–liquid mass transfer coefficient of a stirred vessel equipped with a gas-inducing impeller[J]. Chemical Engineering Science, 2002, 57(16):3299-3306.
[19] Saravanan K, Mundale V D, Patwardhan A W, et al. Power Consumption in Gas-Inducing-Type Mechanically Agitated Contactors[J]. Industrial & Engineering Chemistry Research, 1996, 35(5):1583-1602.

具有双层桨结构的自吸式搅拌反应器的流体力学性能

Hydrodynamics performance of self-inducing stirred tank equipped with double impellers

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	徐胜楠刘宏斐李雪良堵国成陈坚. 鼓泡塔细胞反应器流体力学与传质特性[J]. 过程工程学报, 2022, 22(9): 1192-1202.
[2]	刘洋郭中山赵元琪管小平杨宁. 洗涤冷却室气液两相流的模拟及结构优化[J]. 过程工程学报, 2022, 22(1): 32-40.
[3]	宁尚雷陶芳芳靳海波何广湘杨索和郭晓燕. SEBS高黏度溶液气液鼓泡塔的流体力学研究[J]. 过程工程学报, 2020, 20(7): 779-787.
[4]	韩继康王伟之张伟单志伟王东 . 浮选设备流体力学特征参数研究现状[J]. 过程工程学报, 2020, 20(10): 1121-1133.
[5]	刘凤霞李永强许晓飞董鑫刘志军. 微曝氧化沟气液两相传质模型构建及传质影响因素分析[J]. 过程工程学报, 2019, 19(4): 676-684.
[6]	范兵强张洋郑诗礼冯鑫张懿陈晓芳乔珊. 气液搅拌体系中宏观气含率的预测[J]. 过程工程学报, 2016, 16(4): 565-570.
[7]	杨志方杜峰王杰陈延新吴乐乐. 反应器类型对流动影响的数值模拟[J]. 过程工程学报, 2015, 15(5): 721-728.
[8]	李光晓王钊范怡平卢春喜. 气液两相逆流-错流撞击洗涤器内两相流动与传质特性[J]. , 2015, 15(2): 198-204.
[9]	李鸿莉李阳东李登新印春生. 三相流化床动力学特征的影响因素[J]. , 2014, 14(2): 223-228.
[10]	牛凯远胡堃余孟栗黄卫星. 内循环三相生物流化床反应器中流体的循环速度[J]. , 2014, 14(1): 42-46.
[11]	练以诚靳海波. 气升式内循环反应器的数值模拟和结构参数[J]. , 2012, 12(4): 541-549.
[12]	蔡清白戴干策. 三相浅层鼓泡塔颗粒悬浮特性[J]. , 2011, 11(6): 901-906.
[13]	秦岭靳海波杨索和何广湘朱建华. 多级气液鼓泡塔中筛板结构对气垫层高度及局部气含率的影响[J]. , 2011, 11(1): 9-14.
[14]	李昱喆齐祥明刘天中陈昱. 带波纹隔板的平板式光生物反应器流动特性[J]. , 2010, 10(5): 849-855.
[15]	赵鉴楚包雨云高正明. 电解质对搅拌反应器中气-液分散特性的影响[J]. , 2010, 10(3): 457-461.