鸡白痢沙门氏菌兔抗血清多抗IgG的纯化与稳定

doi:10.12034/j.issn.1009-606X.219153

过程工程学报 ›› 2019, Vol. 19 ›› Issue (6): 1204-1211.DOI: 10.12034/j.issn.1009-606X.219153

鸡白痢沙门氏菌兔抗血清多抗IgG的纯化与稳定

尤星力^1,2，杨延丽¹，苏志国¹，张媛³，张松平^1*

1. 中国科学院过程工程研究所生化国家重点实验室，北京 100190 2. 中国科学院大学化学工程学院，北京 100049 3. 中国兽医药品监察所，北京 100081

收稿日期:2019-03-10 修回日期:2019-04-04 出版日期:2019-12-22 发布日期:2019-12-22
通讯作者: 张松平 spzhang@ipe.ac.cn
基金资助:
国家重点研发计划资助项目;高芳烃高含氮重油催化转化反应基础研究;高芳烃高含氮重油催化转化反应基础研究;国家重点研发计划资助项目

Facile purification and stabilization of anti-Salmonella pullorum polyclonal immunoglobulin G

Xingli YOU^1,2, Yanli YANG¹, Zhiguo SU¹, Yuan ZHANG³, Songping ZHANG^1*

1. State Key Laboratory of Biochemical Engineering, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, China 2. School of Chemical Engineering, University of Chinese Academy of Sciences, Beijing 100049, China 3. China Institute of Veterinary Drug Control, Beijing 100081, China

Received:2019-03-10 Revised:2019-04-04 Online:2019-12-22 Published:2019-12-22
Contact: Song PingZhang spzhang@ipe.ac.cn
Supported by:
National Key Research and Development Program of China;National Key Research and Development Program of China

摘要/Abstract

摘要： 建立了离子交换层析介质一步纯化鸡白痢沙门氏菌兔抗血清获得多抗免疫球蛋白G (IgG)的方法，利用IgG与杂蛋白等电点的差异，指导阴阳离子交换层析介质筛选和操作条件优化；针对多抗IgG易失活的难题，采用差示扫描荧光法为纯化后的IgG筛选稳定剂。结果表明，通过毛细管等电聚焦测得兔抗血清多抗IgG的等电点为6.04?7.08，阳离子交换介质CM Sepharose Fast Flow层析纯化的IgG最高电泳纯度为63.5%，高效液相尺寸排阻色谱测得IgG回收率为15.5%；阴离子交换层析纯化效果更佳，pH 5.5条件下Q Sepharose XL(Q-XL)介质层析获得的IgG最高纯度达99.3%，回收率达67.5%；200 g/L山梨醇对IgG具有最佳稳定作用，IgG的2个热变性温度分别提高了5.52和8.84℃，70℃时山梨醇的稳定作用更明显；以200 g/L山梨醇为稳定剂、用阴离子交换层析介质Q Sepharose XL一步纯化所得IgG具有高纯度、高收率及高稳定性，且制备工艺简单。

关键词: 鸡白痢沙门氏菌, 免疫球蛋白G, 标准物质, 纯化, 等电点, 离子交换层析, 稳定

Abstract: A single step separation protocol was developed for purification of anti-Salmonella pullorum polyclonal immunoglobulins G (IgG) from rabbit serum. According to the difference of isoelectric point (pI) between IgG and the major impurities, the types of ion exchange media were systematically screened by comparison of their purification results. In order to prevent the IgG from denaturation, different stabilizers were screened by differential scanning fluorimetry (DSF). The results showed that pI of the IgG was 6.04?7.08 determined by capillary iso-electric focusing. After cation exchange chromatography with packing materials of CM Sepharose Fast Flow (CM), the purity analyzed by SDS?PAGE was 63.5% and IgG recovery rate measured by high performance size-exclusion chromatography was 15.5%, respectively. In contrast, the purity of IgG was 99.3% and recovery rate was 67.5% after anion exchange chromatography with packing materials of Q Sepharose XL (Q-XL). 200 g/L sorbitol was found to possess the best protection effect. The two thermal denaturation temperatures of IgG were increased by 5.52 and 8.84℃, respectively, and the stability at 70℃ was significantly improved. The results demonstrated that the one step anion exchange chromatography together with 200 g/L sorbitol protection provided a high purity, high recovery rate, and high stability of the IgG. The whole process is facile and efficient.

Key words: Salmonella pullorum, Immunoglobulin G, Reference material, Purification, Isoelectric point, Ion exchange chromatography, Stabilization

尤星力杨延丽苏志国张媛张松平. 鸡白痢沙门氏菌兔抗血清多抗IgG的纯化与稳定[J]. 过程工程学报, 2019, 19(6): 1204-1211.

Xingli YOU Yanli YANG Zhiguo SU Yuan ZHANG Songping ZHANG. Facile purification and stabilization of anti-Salmonella pullorum polyclonal immunoglobulin G[J]. Chin. J. Process Eng., 2019, 19(6): 1204-1211.

参考文献

[1] Wong C L, Sieo C C, Tan W S, et al.Evaluation of a lytic bacteriophage, Φ st1, for biocontrol of Salmonella enterica serovar Typhimurium in chickens [J].International Journal of Food Microbiology, 2014, 172:92-101
[2] 沙莎, 孙裕光, 王琴.我国鸡白痢沙门氏菌病诊断与防治研究概况 [C]. 中国微生物学会兽医微生物专委会学术年会中国畜牧兽医学会生物制品学分会第九次学术研讨会论文集, 2003: 50-53.
[3]张媛, 魏财文, 李建, 等.鸡白痢沙门氏菌阳性血清国家标准品制备用菌株的筛选[J].中国兽药杂志, 2018, 42(3):38-44
[4]Low D, O’Leary R, Pujar N S.Future of antibody purification[J].Journal of Chromatography B, 2007, 848(1):48-63
[5]Newcombe A R, Cresswell C, Davies S, et al.Optimised affinity purification of polyclonal antibodies from hyper immunised ovine serum using a synthetic Protein A adsorbent,MAbsorbent A2P[J].Journal of Chromatography B, 2005, 814(2):209-215
[6]Yang H O, Gurgel P V, Carbonell R G.Purification of human immunoglobulin G via Fc-specific small peptide ligand affinity chromatography[J].Journal of Chromatography A, 2009, 1216(6):910-918
[7]Tishchenko G A, Bleha M, Skvor J, et al.Effect of salt concentration gradient on separation of different types of specific immunoglobulins by ion-exchange chromatography on DEAE cellulose[J].Journal of chromatography B, 1998, 706(1):157-166
[8] Mariam S H S, Ooi C W, Tan W S, et al.Purification of rabbit polyclonal immunoglobulin G with ammonium sulphate precipitation and mixed-mode chromatography [J].Separation and Purification Technology, 2015, 144:133-138
[9]Hober S, Nord K, Linhult M.Protein A chromatography for antibody purification[J].Journal of Chromatography B, 2007, 848(1):40-47
[10]Pessela B C C, Munilla R, Betancor L, et al.Ion exchange using poorly activated supports,an easy way for purification of large proteins[J].Journal of Chromatography A, 2004, 1034(1-2):155-159
[11]Goheen S C, Hilsenbeck J L.High-performance ion-exchange chromatography and adsorption of plasma proteins[J].Journal of chromatography A, 1998, 816(1):89-96
[12]Wang Y, Zhang P Y, Liu S J, et al.Purification of IgG from sera of rabbit and guinea pig by flow-through mode ion-exchange chromatography using DEAE Sepharose Fast Flow column[J].Chromatographia, 2011, 74(3-4):209-214
[13]Wongchuphan R, Tey B T, Tan W S, et al.Purification of rabbit polyclonal immunoglobulin G using anion exchangers[J].Process Biochemistry, 2011, 46(1):101-107
[14]张伦, 罗坚, 周月芳, 等.差示扫描荧光法快速筛选高浓度人免疫球蛋白液体制剂处方[J].中国生物制品学杂志, 2016, 29(9):973-977
[15]Yang Y L, Li H, Li Z J, et al.Size-exclusion HPLC provides a simple,rapid,and versatile alternative method for quality control of vaccines by characterizing the assembly of antigens[J].Vaccine, 2015, 33(9):1143-1150
[16] Wang H L, Levi M S, Del Grosso A V, et al.An improved size exclusion-HPLC method for molecular size distribution analysis of immunoglobulin G using sodium perchlorate in the eluent[J].Journal of Pharmaceutical Biomedical Analysis, 2017, 138:330-343
[17] Lowe D, Dudgeon K, Rouet R, et al.Aggregation, stability, and formulation of human antibody therapeutics[J].Advances in Protein Chemistry and Structural Biology, 2011, 84:41-61
[18]Kayser V, Chennamsetty N, Voynov V, et al.Glycosylation influences on the aggregation propensity of therapeutic monoclonal antibodies[J].Biotechnology Journal, 2011, 6(1):38-44

鸡白痢沙门氏菌兔抗血清多抗IgG的纯化与稳定

Facile purification and stabilization of anti-Salmonella pullorum polyclonal immunoglobulin G

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	张晴吴颉马光辉. 用于超声造影成像的颗粒稳定气泡制备[J]. 过程工程学报, 2022, 22(6): 828-838.
[2]	陈秋汀吴楠吴颉王晓军马光辉. Al-Pickering乳液提高口蹄疫疫苗热稳定性的应用[J]. 过程工程学报, 2022, 22(4): 469-477.
[3]	刘宗浩史清洪. 聚合物接枝对脂肪酶活性及稳定性的影响[J]. 过程工程学报, 2022, 22(4): 506-514.
[4]	杨馨蓉车海英杨轲潘朝梁廖小珍马紫峰. 硬碳负极材料的热稳定性及其钠离子电池安全性能评测[J]. 过程工程学报, 2022, 22(4): 552-560.
[5]	王玮杨锦丁凝陈晓桃唐壁玉. 轻质双相高熵合金Al₂₀Li₂₀Mg₁₀Sc₂₀Ti₃₀热力学性质的第一性原理研究[J]. 过程工程学报, 2022, 22(3): 403-412.
[6]	孙阳王红车海英廖小珍李林森崔桂嘉杨为民马紫峰. ZrO₂包覆对层状氧化物正极材料储钠性能的改善[J]. 过程工程学报, 2022, 22(1): 72-78.
[7]	屈艳玲吴颉马光辉. 基于纤维素纳米晶稳定的亚微米Pickering乳液制备[J]. 过程工程学报, 2021, 21(4): 454-462.
[8]	马艳艳李正军张松平陈卫任瑛. HBc-VLP的分子动力学模拟和结合自由能计算[J]. 过程工程学报, 2021, 21(2): 219-229.
[9]	向杰张松平张贵锋罗坚余蓉. 一步离子交换层析从Cohn组分V上清液中分离人血清白蛋白[J]. 过程工程学报, 2021, 21(1): 92-99.
[10]	冯颖张庆瑾王珏程张建伟. pH对壳聚糖螯合铜(II)的螯合机理及稳定常数的影响[J]. 过程工程学报, 2020, 20(6): 646-654.
[11]	袁俊飞王林王占伟焦永刚. 相变储能冷却系统中储液器的设计与实验研究[J]. 过程工程学报, 2020, 20(12): 1439-1447.
[12]	王艺璇颜成虎丛威. 塑料薄膜材料在微藻培养环境中的稳定性和生物附着行为[J]. 过程工程学报, 2020, 20(1): 74-83.
[13]	葛佳那向明吴学星杨维兴郝冬霞马光辉. 用于单克隆抗体纯化的仿生多肽超大孔PGMA微球制备及其性能[J]. 过程工程学报, 2020, 20(1): 84-90.
[14]	陶娇丽黄永东赵岚朱凯吴学星周丹妮苏志国马光辉刘红缨. 新型电荷型纳米盘的可控制备及其与细胞色素P450的结合性能[J]. 过程工程学报, 2019, 19(6): 1197-1203.
[15]	吴楠吴颉苗春宇马光辉安文琪. 基于纳米氢氧化铝颗粒的Pickering乳液制备[J]. 过程工程学报, 2019, 19(6): 1220-1227.